Food Establishment Inspection Report
Page 1  of ????????? 
Lake logo Lake County Health Department
and Community Health Center
500 West Winchester Road Suite 102
Libertyville, IL 60048
Establishment
 ON THE BORDER 		License/Permit #
 003078
Street Address
535 N LAKEVIEW PKWY
City/State
 VERNON HILLS, IL 		ZIP Code
 60061
No. of Risk Factor/Intervention Violations 1
No. of Repeat Risk Factor/Intervention Violations 0
Date 05/25/2023
Time In 10:45 AM
Time Out 12:00 PM
Permit Holder/Person Interviewed/Person In Charge (PIC)
CHADERSON PASCOAL 		Risk Category
High
Purpose of Inspection   Routine

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
 Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible    

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
 Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected    
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized    
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures X  
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition    
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used    

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
 Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36   Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37 X Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39   Contamination prevented during food preparation, storage & display    
40   Personal cleanliness    
41   Wiping cloths: properly used & stored    
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43   In-use utensils: properly stored    
 Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45   Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47   Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean   X

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54   Garbage & refuse properly disposed; facilities maintained    
55   Physical facilities installed, maintained & clean    
56   Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58   Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishment: ON THE BORDER License/Permit #: 003078 Date: 05/25/2023
Water Supply:   Community Non-Community Licensed Non-Community    Waste Water System:   Community On-Site IEPA System
Sanitizer: Temperature Logs in Use:
Location Method Sanitizer Type Concentration (PPM) Heat(F)
3-Compartment Sink Chemical Sanitizer Quaternary Ammonium 200 0.00
LT Dish Machine Chemical Sanitizer Chlorine 50 0.00
CFPM Verification (name, expiration date, ID#):
CHADERSON PASCOAL
03/12/2027
110856 		     
Presentation Type: STANDARD Number Attended: 1
HACCP Discussed HACCP Principle Plan Onsite
2. Determine the CCP Discussed the HACCP principle of identifying critical control points in your processes such as hot holding at 135 degrees F or above, cold holding at 41 degrees F or below and at freezing for frozen foods and 165 degrees F for reheating. Yes

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
HAMBURGER/COOK'S LINE COOLER 40.00°F CHORIZO/COOK'S LINE COOLER 40.00°F COOKED ONION/COOK'S LINE COOLER 39.00°F
SOUR CREAM/REACH-IN COOLER 37.00°F STUFFED PEPPERS/REACH-IN COOLER 39.00°F SOUP/WALK-IN COOLER 35.00°F
BEEF/STEAM TABLE 166.00°F CHICKEN/STEAM TABLE 160.00°F BEANS/STEAM TABLE 157.00°F
SAUCE/STEAM TABLE 153.00°F CHICKEN/COOKING 178.00°F BEANS/COOKING 178.00°F
BEEF/COOLING 38.00°F        

OBSERVATIONS AND CORRECTIVE ACTIONS
P=Priority      PF=Priority Foundation      C=Core      R=Repeat
Item
Number 		P/PF/C/R Code Reference Violations cited in this report must be corrected within the time frames below.
21 P 3-501.16(A)(1) (A) TIME/TEMPERATURE CONTROL FOR SAFETY FOOD shall be maintained: (1 ) At 135°F or above
Rice at 116 degrees in the steam table. Do not double pan foods if 135 degrees and above can not be met. Corrected, the food was re heated to 165 degrees and above.
Reheat food to 165 F or above and take all necessary steps to assure your hot holding unit is functioning properly.
CORRECTED
37 C 3-602.11 (D) (D) Bulk, unpackaged FOODS such as bakery products and unpackaged FOODS that are portioned to CONSUMER specification need not be labeled if: (1) A health, nutrient content, or other claim is not made; (2) There are no state or local LAWS requiring labeling; and (3) The FOOD is manufactured or prepared on the PREMISES of the FOOD ESTABLISHMENT or at another FOOD ESTABLISHMENT or a FOOD PROCESSING PLANT that is owned by the same PERSON and is regulated by the FOOD regulatory agency that has jurisdiction.
A bulk food containers in dry storage are not labeled.
Provide the required labeling for the product.
CORRECT BY NEXT ROUTINE INSPECTION
49 C, R 4-601.11 (C) Nonfood-CONTACT SURFACES of EQUIPMENT shall be kept free of an accumulation of dust, dirt, FOOD residue, and other debris.
The warmer units for chicken are soiled. A rolling cart and ladder are soiled. The flat grill is soiled. Rolling rack shelves in the walk in cooler are soiled.
Complete detailed cleaning and sanitizing of the item(s) as required.
Repeat,CORRECT BY NEXT ROUTINE INSPECTION
CHADERSON PASCOAL
Person In Charge (Signature)  		Lee Spiegel
Inspector 
Follow-up:  Yes   No   Follow-up Date: